Expanding The Ethanol Blend Wall - A Role For E85?

We began a discussion of the potential domestic blend wall for ethanol in a post in May of last year. The issue remains important for the biofuels industry, regulators, and policy makers. Domestic ethanol consumption is almost entirely in the form of low level blends with gasoline capped at 10 percent (E10), although small amounts have been consumed in "flex fuel" vehicles as an 85 percent blend (E85) and very small quantities are being consumed as a 15 percent blend (E15). With blending dominated by E10, the blend wall is reached when the ethanol inclusion rate reaches 10 percent of domestic motor gasoline consumption. The blend wall can be problematic since the federal Renewable Fuels Standards (RFS) require increasing quantities of renewable (ethanol) biofuels consumption for the next three years. Those requirements exceed the expected E10 blend wall (Figure 1).

There are several ways that the E10 blend wall can either be accommodated or expanded. The blend wall could be accommodated with some combination of two alternatives:

1. The difference between the blend wall and the RFS mandate could be met with the use of RINS credits accumulated by obligated blenders from blending in excess of the RFS in previous years. This alternative is available until credits are exhausted. Blenders used some of those credits in the latter part of 2012, with the year-ending inventory likely less than two billion gallons. We project this stock of RINS credits will be used up sometime in early 2014 at present trends, so this is not likely to be a longer-term solution the E10 blend wall.
2. Some of the RFS for renewable biofuels (ethanol) can be met with discretionary blending of advanced biofuels in excess of the RFS mandate for this category of biofuels. That alternative is currently limited by the increasing RFS for advanced biofuels and the economic loss associated with blending those biofuels (biodiesel and Brazilian ethanol). See our recent post here for estimates of these losses.

There are also two ways to expand the blend wall itself:

1. Increase the consumption of domestic gasoline so that larger amounts of fuel are available for blending. Such increases are expected to be very small for the near future due to weak economic growth and the increasing fuel efficiency of the U.S. car and truck fleet. Motor fuel consumption projections for 2013 are expected to be released by the EPA shortly.
2. Consumption of E15 and E85 could be expanded so that more ethanol can be consumed without an increase in motor fuel consumption. Blending of E15 has been approved by the EPA for 2001 and newer vehicles, but implementation continues to be constrained by a number of factors. These include the very limited number of E15 fueling stations in the U.S. (10 at present), lack of clarification of liability issues associated with dispensing E15, and the need for engine warranties for E15. To date only GM and Ford have warrantied 2012 or 2013 models for E15.

E85 may offer a partial solution for expanding the ethanol blend wall. E85 has been in the market for a number of years and there are currently a number of fueling stations for E85. The U.S. Department of Energy (DOE) estimates that number at 2,311, although this private source estimates the number at 3,043 stations in 2,043 cities. Based on these estimates, 2 to 2.5 percent of the fuel stations in the U.S. offer E85. Analysis by the DOE suggests that the current retail infrastructure could support E85 use of 600 million gallons annually compared to the current consumption of approximately 125 million gallons. Applying the DOE analysis to the private estimate of the number of E85 fueling stations would increase that estimate from 600 million gallons to 790 million gallons. The EPA also estimates that there are over 10 million flex fuel vehicles in service presently in the U.S. At average annual driving distances, that number is sufficient to consume several billion gallons of E85 annually.

With some additional fueling capacity, it might be feasible to consume 800 to 900 million gallons of E85 annually, which would expand the ethanol blend wall to about 14.2 to 14.3 billion gallons with no increase in total fuel consumption and no significant consumption of E15. Depending on the amount of Brazilian ethanol imports (which displaces domestic ethanol under a blend wall constraint) that would be close to meeting the RFS for renewable biofuels through 2014. The RFS for 2015, however, rises to 15 billion gallons.

Source: Farmdocdaily.illinois.edu